MATERIAL SAFETY DATA SHEET

OSHA FORM 174

 

PRODUCT NAME: APC 120 WX

PRODUCT CODE: 9004

HMIS CODES: H - 1  F - 0  R - 0  P - B

(HEALTH - FIRE - REACTIVITY - PERSONAL PROTECTION)

HMIS RATING: 0=MINIMAL, 1=SLIGHT, 2=MODERATE, 3=SERIOUS, 4=SEVERE

 

SECTION I - MANUFACTURER IDENTIFICATION

 

MANUFACTURER'S NAME: WINSOL LABORATORIES, INC.

ADDRESS:                            1417 NW 51ST, SEATTLE, WA. 98107

EMERGENCY PHONE:      206/782-5500

DATE PREPARED: 10-01-05  NAME OF PREPARER: WINSOL LABORATORIES, INC.

REVISED: 01-01-12

 

SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION

 

HAZARDOUS         CAS #                                                    OSHA         ACGIH       OTHER                VAPOR                      WEIGHT

COMPONENTS                                                                      PEL            TLV                                       PRESS                        %

-----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------

 NONE                                                                   

SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS

 

 

BOILING POINT: OVER 200 DEG. F.                     SPECIFIC GRAVITY (H2O=1): 1.049

VAPOR DENSITY: NA                                              EVAPORATION RATE: <1

V.O.C.:  NA                                                               ETHER=1)   

SOLUBILITY IN WATER: 100%            

APPEARANCE AND ODOR: AMBER, LEMON                        

pH 10.5 Lower in usage range (meets NFPA standards for mild detergent pH range between 6.0 to 10.5 pH)

             

SECTION IV - FIRE AND EXPLOSION HAZARD DATA

                                     

APC 120 WX IS CONSIDERED NON-FLAMMABLE

FLASH POINT: NA                                

FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: NA UPPER: NA    

EXTINGUISHING MEDIA: WATER                                                                          

SPECIAL FIRE FIGHTING PROCEDURES: SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE OPERATED IN A PRESSURE DEMAND OR OTHER POSITIVE PRESSURE MODE.

UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE

 

SECTION V - REACTIVITY DATA

 

STABILITY:  STABLE

CONDITIONS TO AVOID: STRONG OXIDIZING AGENTS, ACIDS

INCOMPATIBILITY (MATERIALS TO AVOID): NONE                                                        

HAZARDOUS DECOMPOSITION OR BYPRODUCTS: NONE                                                                                                       

HAZARDOUS POLYMERIZATION: WILL NOT OCCUR

 

SECTION VI - HEALTH HAZARD DATA

 

INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND RESPIRATORY IRRITATION.

SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE:  

EYE: MAY CAUSE MODERATE EYE IRRITATION AND SLIGHT CORNEAL INJURY. VAPORS MAY IRRITATE EYES. IN ANIMALS,

IRRITATION AND CORNEAL INJURY HEALED PRIMARILY WITHIN 8 DAYS. 

SKIN: PROLONGED OR REPEATED AND CONFINED EXPOSURE MAY CAUSE SKIN IRRITATION. REPEATED CONTACT MAY CAUSE

DRYING OR FLAKING OF SKIN.

SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: A SINGLE PROLONGED EXPOSURE IS NOT LIKELY TO RESULT IN THE MATERIAL BEING ABSORBEDTHROUGH THE SKIN IN A HARMFUL AMOUNT. THE DERMAL LD50 HAS NOT BEEN DETERMINED.

INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: SWALLOWING CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.

CARCINOGENICITY: THIS MATERIAL IS NOT CONSIDERED TO BE A CARCINOGEN BY THE NATIONAL TOXICOLOGY PROGRAM, THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER, OR THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION.

 NTP? NO    IARC MONOGRAPHS? NO    OSHA REGULATED? NO

EMERGENCY AND FIRST AID PROCEDURES:

EYES    IRRIGATE WITH FLOWING WATER IMMEDIATELY AND CONTINUOUSLY FOR 15 MINUTES. CONSULT MEDICAL PERSONNEL.

SKIN     WASH OFF IN FLOWING WATER OR SHOWER. REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE.

 

 

                9004

SECTION VI - HEALTH HAZARD DATA - CONT.

 

INGESTION DO NOT INDUCE VOMITING. CALL PHYSICIAN AND/OR TRANSPORT TO EMERGENCY FACILITY IMMEDIATELY.

INHALATION  REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE MOUTH TO MOUTH RESUSCITATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL A PHYSICIAN.         

 

SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE

 

STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:

SMALL SPILL- ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER ABSORBENT MATERIAL AND TRANSFER TO LABELED CONTAINERS.

LARGE SPILL- STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PREVENT SPREADING, PUMP LIQUID INTO SALVAGE TANK. REMAINING LIQUID MAY BE TAKEN UP ON SAND, CLAY, and FLOOR ABSORBENT OR OTHER ABSORBENT MATERIAL AND SHOVELED INTO CONTAINERS.

WASTE DISPOSAL METHOD: REVIEW FEDERAL, PROVINCIAL AND LOCAL GOVERNMENT REQUIREMENTS PRIOR TO DISPOSAL       

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING EXERCISE REASONABLE CARE AND CAUTION. STORE IN A COOL PLACE.

OTHER PRECAUTIONS: CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED, SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID AND/OR SOLIDS), ALL HAZARD PRECAUTIONS GIVEN IN THE DATA SHEET MUST BE OBSERVED.

 

SECTION VIII - CONTROL MEASURES

 

RESPIRATORY PROTECTION: IF TVL OF THE PRODUCT OR ANY COMPONENT IS EXCEEDED, A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA RESPIRATORS UNDER SPECIFIED CONDITION.

VENTILATION:  PROVIDE GENERAL OR MECHANICAL VENTILATION OR LOCAL EXHAUST TO KEEP VAPOR CONCENTRATIONS BELOW TLV OF MATERIALS IN SECTION II AND LEL IN SECTION IV.

PROTECTIVE GLOVES: USE IMPERMEABLE GLOVES TO PREVENT PROLONGED SKIN CONTACT.

EYE PROTECTION: USE SAFETY EYEWEAR DESIGNED TO PROTECT EYES AGAINST LIQUID SPLASH AND MISTS. CONSULT YOUR SAFETY EQUIPMENT SUPPLIER.

OTHER PROTECTIVE CLOTHING OR EQUIPMENT: USE PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT. USE HEAD CAPS, BOOTS, CHEMICAL APRONS WHEN NECESSARY.

WORK/HYGIENIC PRACTICES: EYEWASHES AND SAFETY SHOWERS IN THE WORK PLACE ARE RECOMMENDED.  WASH HANDS AFTER USING. MONITOR-EXPOSURE LEVELS.

 

SECTION IX - OTHER REGULATORY INFORMATION

 

SARA TITLE III / SECTION 313 SUPPLIER NOTIFICATION

THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE THREE OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND OF 40 CFR 372:

CAS: #          CHEMICAL NAME                PERCENT BY WEIGHT

NONE

 

NEW JERSEY: UNDER THE NEW JERSEY RIGHT-TO-KNOW ACT, THE TOP FIVE SUBSTANCE MUST BE LISTED ON YOUR LABEL OR TRADE SECRET REGISTRY NUMBERS.TRADE SECRET REGISTRY NUMBERS:  TSRN 80100256-5000P,TSRN 80100256-5001P,TSRN 80100256-5002P,TSRN 80100256-5003P,TSRN 80100256-5004P, TSRN 80100256-5005P.

               

SECTION X - DISCLAIMER

 

NOTICE:  ALTHOUGH THE INFORMATION AND RECOMMENDATIONS SET FORTH HEREIN (HEREINAFTER "INFORMATION") ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE CORRECT AS OF THE DATE HEREOF, WINSOL LABORATORIES, INC. MAKES NO REPRESENTATIONS AS TO THE COMPLETENESS OR ACCURACY THEREOF.  INFORMATION IS SUPPLIED UPON THE CONDITION THAT THE PERSONS RECEIVING SAME WILL MAKE THEIR OWN DETERMINATION AS TO THE SUITABILITY FOR THEIR PURPOSES PRIOR TO USE.  IN NO EVENT WILL WINSOL LABORATORIES, INC. BE RESPONSIBLE FOR DAMAGES OF ANY NATURE WHATSOEVER RESULTING FROM THE USE OF OR RELIANCE UPON INFORMATION.  NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR OF ANY OTHER NATURE ARE MADE HEREUNDER WITH RESPECT TO INFORMATION OR THE PRODUCT TO WHICH INFORMATION REFERS. 

 

TLV IS A REGISTERED TRADEMARK OF THE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH).

REVISED

01-01-12